How Many Turns On Awning Spring

The torsion spring will be wound with 8 eight more turns in this position and is extremely dangerous.

How many turns on awning spring. Prov23 4 do not wear yourself out to get rich. Attach the vice grips to the new ratchet assembly and rotate as many turns as noted in step 6. On the front spring counter clockwise 8 turns. Only rotate the legs one or two turns at a time and don t do more than 4 or 5 total.

Remember you are adding the initial turns to the turns that the awning gets as it unrolls. Then the chart indicates 10 turns. 2003 15 foot a e dometic 8500. New dometic heavy duty springs installed on a 19 8500 awning set at 8 turns do not retract the awning without me pushing it up.

Here s the recommended number of turns but keep in mind the older the assembly the more likely you ll have to add one or two more. I just replaced a spring on mine and the factory rep said 7 turns for an 18 awning. Generally it will take six turns for awning lengths of 8 to 12 feet seven turns for 13 to 14 feet eight turns for 15 to 16 feet 10 turns for 17 to 18 feet 11 turns for 19 to 21 feet and 12 turns for 22 to 25 feet. Most awnings have a spring on both ends of the tube.

Extended 17 turns. Reinsert the end cap into the awning arm and install the bolt. If the springs are older and wound too tight they can break. How tight can i safely read more.

The unwinding can also be done while standing on the ground and the awning fully extended and the opposite side rafter locked in place. Jim and jennie cats bittles and potter 2000 dynasty 350 isc. On the left spring rear turn clockwise about 8 turns. Have the wisdom to show restraint.

If you over tighten the spring it will break. You do not need to put the screws back in. Turn the spring top away from the coach. Roll the awning back up to observe how tight it is.

This will depend on the spring and tube length. The trick is to get the awning to roll up fully and completely without slamming back against the coach. Severe injuries can result from the rapid spin off of the top casting. If you are satisfied move on.

2013 silverado 4x4 towed with r1200gs in bed. If not then repeat the previous steps. Travel position 9 turns.